CSL100MV ManualEN 062007.qxp 9/26/08 11:22 AM Page I
SPORTSPOT®
1,000,000 SPOTLIGHT
INSTRUCTION MANUAL
Catalog Number CSL100MV
TO REDUCE THE RISK OF INJURY, THE USER MUST READ
AND UNDERSTAND THE INSTRUCTION MANUAL.
SAVE THIS MANUAL FOR FUTURE REFERENCE.
Cat. # CSL100MV
Form # 90519934
Copyright © 2007 Black & Decker
June 2007
Printed in China
CSL100MV ManualEN 062007.qxp 9/26/08 11:22 AM Page 2
SAFETY GUIDELINES / DEFINITIONS
DANGER: Indicates an imminently hazardous situation which, if not avoided, will result
in death or serious injury.
WARNING: Indicates a potentially hazardous situation which, if not avoided, could
result in death or serious injury.
CAUTION: Indicates a potentially hazardous situation which, if not avoided, may result
in minor or moderate injury.
CAUTION: Used without the safety alert symbol indicates potentially hazardous situation
which, if not avoided, may result in property damage.
WARNING: RISK OF UNSAFE OPERATION: When using tools or equipment, basic
safety precautions should always be followed to reduce the risk of personal injury.
Improper operation, maintenance or modification of tools or equipment could result in
serious injury and property damage. There are certain applications for which tools and
equipment are designed. Black & Decker strongly recommends that this product NOT be
modified and/or used for any application other than for which it was designed. Read and
understand all warnings and operating instructions before using any tool or equipment.
IMPORTANT SAFETY INSTRUCTIONS
WARNING: This product or its power cord contains lead, a chemical known to the
State of California to cause cancer and birth defect or other reproductive harm. Wa s h
hands after handling.
WARNING: TO REDUCE THE RISK OF ELECTRIC SHOCK:
• Do not operate unit with damaged cord or plug; or if the unit has received a sharp blow,
been dropped, or otherwise damaged in any way.
• Do not open body casing. There are no user- s e rviceable parts inside; take it to a qualified
ser vice technician when service or repair is required. Incorrect reassembly may result in a
risk of electric shock or fire, and will void warranty.
WARNING: FIRE HAZARD: Never contact combustible material to the lens and never
tape the switch in the ON position.
CAUTION: TO REDUCE THE RISK OF INJURY OR PROPERTY DAMAGE:
• All halogen lights give off heat:
– Do not plug in a power supply without the bulb lens and cover in place.
– Do not touch lens while operating.
– Keep combustibles away from spotlight lens. Extreme heat can cause fires.
– Never place the light face-down on any surface when lit.
• DO NOT expose this unit to extremely high temperatures.
• Never look directly into the light or shine the light into another person’s eyes.
• Keep sharp objects away from lens – it is glass and can break.
2
CSL100MV ManualEN 062007.qxp 9/26/08 11:22 AM Page 3
• Do not immerse spotlight in water.
• Do not drop or throw spotlight. It contains glass and a sealed lead acid battery.
• Only replace bulb with type indicated in specifications (H3, 12 volt quartz halogen).
• Do not crush, cut, pull or expose charging adapter cords to extreme heat.
• Position charging adapter cords so they do not become entangled or become a safety
hazard. Keep cords away from sharp edges.
• Use in a dry location only.
• Do not operate this unit with a missing or damaged guard or glass lamp containment
barrier.
• Do not use any accessory not supplied or recommended by the manufacturer.
• To reduce risk of damage to electric plug and cord, pull by plug rather than cord when
disconnecting from the 12 volt DC outlet.
• Do not attempt to use the unit if the 12 volt DC plug or cord are damaged – return the
unit to manufacturer for repair.
• Read And Understand This Instruction Manual Before Using This Unit.
SAVE THESE INSTRUCTIONS
THIS MANUAL CONTAINS IMPORTANT SAFETY AND OPERATING INSTRUCTIONS FOR
THE SPORTSPOT® 1,000,000 SPOTLIGHT MODEL CSL100MV.
WARNING: TO REDUCE THE RISK OF INJURY:
• Follow these instructions and those published by the manufacturer of any equipment you
intend to use with this unit. Review cautionary markings on these products.
INTRODUCTION
Thank you for choosing the CSL100MV SportSpot® 1,000,000 Spotlight. Please read this
manual carefully before use to ensure optimum performance and avoid damage to the unit.
FEATURES
• A compact, powerful quartz halogen spotlight
• Power ful quartz halogen bulb delivers a bright, tight beam
• Computer-designed parabolic reflector
• Compact, lightweight design
• Pistol grip handle design fits comfortably in your hand
• On/Off spring-loaded power switch delivers an instant beam
• Can be used with Black & Decker® jump starters for portability
• Hanging hook for convenient storage
3
CSL100MV ManualEN 062007.qxp 9/26/08 11:22 AM Page 4
Controls and Indicators
HALOGEN BULB
HANGING
HOOK
BLUE-TINTED
LENS
SPRING-LOADED
ON/OFF SWITCH
RUBBER
BEZEL
HEAVY DUTY CORD &
FUSED DC PLUG
OPERATING INSTRUCTIONS
1. Insert the SportSpot® spotlight 12 volt DC plug into the accessory socket of your
vehicle or a portable 12 volt power source, such as a jump starter.
2. To turn on the SportSpot® slide the spring-loaded power switch to the ON position (up).
3. To turn off the SportSpot®, release the spring-loaded power switch. It will slide back to
the OFF position (down).
USING THE HANGING HOOK
The Hanging Hook allows you to position the unit for convenient, hands-free operation.
CAUTION: TO REDUCE THE RISK OF PRODUCT DAMAGE:
• When Hanging Hook is in use, do not shake light.
• When light is hung by the Hanging Hook, do not shake the light or object that it is hanging
from. Do not hang the light from any electrical wires or anything that it is not secure.
• Only use the Hanging Hook for hanging this unit. The Hanging Hook is not intended to
support additional weight. Do not attach or hang anything additional to the light or risk of
breakage may occur.
USING THE BLUE-TINTED LENS
To use the included blue-tinted lens:
1. With the unit turned off, remove the protective bezel.
2. Place the blue lens over the face of the unit in the bezel grooves.
3. Operate the unit normally.
Refer to the following illustration for guidance.
4
CSL100MV ManualEN 062007.qxp 9/26/08 11:22 AM Page 5
CAUTION: Do not operate the spotlight without either the original bezel or the blue lens in
place over the bulb assembly.
CARE AND MAINTENANCE
This unit is NOT waterproof. Never submerge this unit in water. If it gets dirty, gently clean
the outer surfaces with a soft cloth moistened with a mild solution of water and detergent.
Bulb Replacement
1. Disconnect the SportSpot® from the power source.
2. Remove rubber bezel.
3. Loosen and remove six screws that secure spotlight housing.
4. Lift up and set aside the right side of the housing.
5. Remove wire spring and carefully pull out old bulb from the terminal.
6. Replace with a new H3 type, 12 volt, 100 watt bulb, available from an electrical supply
house or from Black & Decker (refer to the Service Information section).
7. Reverse the above procedure to re-assemble the spotlight.
Note: When handling a new halogen bulb, do not touch the glass portion of the bulb.
Natural oils from your hands can cause the bulb to fail. If necessary, clean the bulb
with alcohol or a liquid window cleaner.
Fuse Replacement (12 Volt DC Plug)
If the inverter is overloaded, and the Power/Fault LED is not lit, the internal 8 amp fuse
may be blown.
1. Unscrew the flange of the DC plug (counterclockwise).
2. Remove the end contact, flange and fuse.
3. Inspect the fuse to see if it is good or blown.
4. Replace with a new 8 amp fuse, if needed.
5. Carefully reassemble the fuse, end contact and flange. Do not overtighten the flange
(clockwise).
5
CSL100MV ManualEN 062007.qxp 9/26/08 11:22 AM Page 6
Accessories
Recommended accessories for use with your tool are available from your local dealer
or authorized service center. If you need assistance regarding accessories, please call:
1-800-544-6986.
WARNING: The use of any accessory not recommended for use with this tool could be
hazardous.
Service Information
All Black & Decker Service Centers are staffed with trained personnel to provide customers
with efficient and reliable power tool service. Whether you need technical advice, repair, or
genuine factory replacement parts, contact the Black & Decker location nearest you. To find
your local service location, refer to the yellow page directory under "Tools—Electric" or call:
FULL ONE-YEAR HOME USE WARRANTY
Black & Decker (U.S.) Inc. warrants this product for one year against any defects in material
or workmanship. The defective product will be replaced or repaired at no charge in either of
two ways.
The first, which will result in exchanges only, is to return the product to the retailer from
whom it was purchased (provided that the store is a participating retailer). Returns should be
made within the time period of the retailer’s policy for exchanges (usually 30 to 90 days after
the sale). Proof of purchase may be required. Please check with the retailer for their specific
return policy regarding returns that are beyond the time set for exchanges.
The second option is to take or send the product (prepaid) to a Black & Decker owned or
authorized Service Center for repair or replacement at our option. Proof of purchase may be
required. Black & Decker owned and authorized Service Centers are listed under "Tools-
Electric" in the yellow pages of the phone directory and on our website
This warranty does not apply to accessories. This warranty gives you specific legal rights
and you may have other rights which vary from state to state or province to province.
Should you have any questions, contact the manager of your nearest Black & Decker Serv i c e
Center. This product is not intended for commercial use.
FREE WARNING LABEL REPLACEMENT: If your warning labels become illegible or are
missing, call 1-800-544-6986 for a free replacement.
SPECIFICATIONS
Spotlight Bulb:
DC Plug Fuse:
H3, 12 volt, 100 watt
8 amp, 250 VAC
Imported by
Black & Decker (U.S.) Inc.,
701 E. Joppa Rd.
Towson, MD 21286 U.S.A
RD062007
6
|